实时新闻资讯·带您了解各种类型的水上乐园

服务热线电话

400-840-8766

循环水泵的维护与检修事项

来源:https://www.hcseaworld.com/ 日期:2022-09-24 发布人:admin 浏览量:

循环水泵在正常生产工作中会经常用到,尤其是在水上乐园中作为一个水处理设备使用,当然它也是需要进行维护与检修工作的,下面水上乐园设备厂家就来讲讲相关事项。
The circulating water pump is often used in normal production, especially as a water treatment equipment in the water park. Of course, it also needs to be maintained and overhauled. The following equipment manufacturers of the water park will talk about relevant matters.
1、每天查看循环泵的运行声音是否正常,有没有振动或者漏气情况,一旦发现问题及时解决与处理。
1. Check whether the running sound of the circulating pump is normal and whether there is vibration or air leakage every day. Once problems are found, solve them in time.
2、每天查看循环泵悬挂油室内的油位是否合适,需要保持在油标的三分之一与二分之一处。
2. Check whether the oil level in the suspension oil chamber of the circulating pump is proper every day, and keep it at one-third and one-half of the oil pointer.
3、时刻保持设备的清洁、干燥、没有油污与渗漏。
3. Keep the equipment clean, dry and free from oil stain and leakage at all times.
4、强制循环泵严禁金属物体、面纱、橡胶片、塑料布等柔性物质进入,以免对流体的过流部件造成损坏,防止堵塞叶轮通道,使循环泵不能正常工作。
4. The forced circulation pump is strictly prohibited from metal objects, veils, rubber sheets, plastic cloth and other flexible substances, so as to avoid damage to the flow passage parts of the fluid, and to prevent blocking the impeller channel, so that the circulation pump can not work normally.
5、禁止循环泵在池内液体排空的情况下工作,循环水泵不但在排空的情况下进行剧烈振动,还会对循环泵的使用寿命造成影响需要特别注意。
5. It is forbidden to operate the circulating pump when the liquid in the pool is drained. The circulating pump not only vibrates violently when it is drained, but also affects the service life of the circulating pump. Special attention should be paid to this.
6、填料密封的循环泵应该定期查看填料函处的泄露。填料函处的轴承泄露应该每分钟在10滴到20滴。否则应该调整压盖的松紧度位置。
6. For the circulating pump with packing seal, check the leakage at the stuffing box regularly. The bearing leakage at the stuffing box should be 10 to 20 drops per minute. Otherwise, the tightness position of the gland should be adjusted.
7、定期查看爪型联轴器的同心度。
7. Regularly check the concentricity of the jaw coupling.
8、在循环水泵运行的前一个月,运行100小时后需要对悬架油室中的润滑油进行更换,并在循环水泵运行后的每500小时对润滑油进行更换。
8. The lubricating oil in the suspension oil chamber shall be replaced one month before the circulating water pump runs for 100 hours, and the lubricating oil shall be replaced every 500 hours after the circulating water pump runs.
水上乐园设备厂家
9、经常查看轴承温度,较高温度不可以超出70℃~75℃。
9. Check the bearing temperature frequently, and the higher temperature shall not exceed 70 ℃~75 ℃.
10、经常查看循环泵基础紧固螺栓的紧固情况,保证连接牢固可靠。
10. Check the fastening of the fastening bolts of the circulating pump foundation frequently to ensure that the connection is firm and reliable.
11、经常查看循环泵进出口管路系统的支撑机构是否出现松动,保证支撑机构的牢固性,泵体不能承受支撑力。
11. Check frequently whether the supporting mechanism of the inlet and outlet pipeline system of the circulating pump is loose to ensure the firmness of the supporting mechanism, and the pump body cannot bear the supporting force.
12、安装在生产系统中的备用循环泵长期不运转时,应该每周旋转四分之一圈,使泵轴均匀的承受静载荷与外界振动。
12. When the standby circulating pump installed in the production system is not running for a long time, it should rotate for a quarter of a circle every week to make the pump shaft bear static load and external vibration evenly.
13、循环泵运行约2000小时后应该进行定期检查,维修或者更换损坏的部件,可以使低温循环泵长时间处于良好的状态。
13. After the circulating pump runs for about 2000 hours, it should be checked regularly, repaired or replaced with damaged parts, which can keep the cryogenic circulating pump in good condition for a long time.
14、热水循环泵长时间不使用时应该把循环水泵拆开进行防锈处理再重新组装,并妥善保管用来下次使用。
14. When the hot water circulating pump is not used for a long time, it should be disassembled for rust prevention treatment and reassembled, and properly kept for next use.
15、循环泵电机断电时管道内液体的逆流可以使循环水泵出现反转。需要特别注意的是循环泵输送高差特别大时,应该在管道上设置止回阀避免回水倒灌,控制循环泵的突然反转。
15. When the circulating pump motor is powered off, the reverse flow of liquid in the pipeline can make the circulating pump reverse. It should be noted that when the delivery elevation difference of the circulating pump is especially large, a check valve should be set on the pipeline to avoid backwater backflow and control the sudden reversal of the circulating pump.
循环水泵的维护与检修事项就讲到这里了,对此内容希望您可以好好考虑,更多注意事项就来我们网站https://www.hcseaworld.com咨询吧!
That's all for the maintenance and overhaul of the circulating water pump. I hope you can take this into consideration. More precautions can be found on our website https://www.hcseaworld.com Consult!

需要一些帮助选择吗?

我们有一个行业专家团队,他们很乐意与您讨论您的项目及其需求,
以帮助您找到合适的人选。
让我们开始吧 咨询电话:15662636467

网站导航

服务热线

400-840-8766

汇川·致力于创新与普及软体水上乐园

  • 【安经理】

  • 【张经理】

  • 【技术咨询】

  • 【售后服务】

济南汇川环保科技有限公司 地址:济南市市中区罗而工业园

技术支持:网站建设·推广运营备案:鲁ICP备20031739号-3

在线留言

聚力汇川·达成共识信任汇川合作共赢
  • 您的姓名:
    您的电话:
    您的地址:
  • 选择项目:
  • 您的需求:
  •  

截屏,微信识别二维码

微信号:hc19861811151